401

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

The small report on alteration of system of cooling Dune D1 + WD20EARS (three plates)
The reason:
The considerable heating of the screw at setting on a shelf
Tight enough
The temperature sometimes reached 60 wasps
Especially in a downloading mode on the dune screw
Initial data:
At the removed cover temperature in loading -
Playback 1080 + parallely downloading from an Internet on the dune screw
After three hours of 41 wasps .
Now variants of an upgrade WITH
Variant No1
Instead of a regular cover made same, but with punching
Stainless steel 0.6, adjustment - not ideal
But allows to define efficiency of punching
[img=200x169, 11.2Kb] http://album.foto.ru:8080/photos/sm/193086/2030990.jpg [/img]
Test mode - the same, as above
Temperature of the maximum 48 wasps (3 hours)
Variant No2
All known with a screw clip to the upper plane of a native cover
And changeover of a sled of fixing of the screw
[img=81x200, 7.9Kb] http://album.foto.ru:8080/photos/sm/193086/2030991.jpg [/img]
Result
Already transited almost 4 hours (the second avatar soon ends)
The temperature above 45 wasps did not rise
I suspect it to stop and consider such WITH
Optimal at saving of appearance of a player and  warranties

Only I will buy still a normal thermospacer in exchange ,
Which managed to be torn off with  FROM mine  3870 and 5870
The thermospacer is necessary, since the upper plane of my screw does not nestle on a cover
The edge on the perimeter, designated on 2nd photo a red arrow hinders....

402

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

wats0n , and what temperature was in a room (round a player) during testing? And what will be temperature HDD in summer heat when in a room will be very much hot? It is clear that  can rescue a situation, but all the same...

403

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

THE GRIZZLY
Forgot to specify
In all cases in a room there were 25 wasps

404

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

For it is passive drawn in to a cover  the forecast for "heat" it is possible to make estimately a direct proportion of the data from pictures - on how many increases selected red exterior t-ra, on grows and selected green t-ra S.M.A.R.T so much.
[off] - yellow there it is selected t-ra air from the exterior sensor fixed under a disk [/off]
[off] - the second picture with a bit best t-rami is at the pinches extended on 2 sm [/off]
[img=492x369, 29,4Kb] http://forum.ibt/post.cgi?id=attach:60:2002:426:1 [/img] [img=492x369, 30,8Kb] http://forum.ibt/post.cgi?id=attach:60:2002:426:2 [/img]

405

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

Scalability of such method of cooling of the screw, as a clip to a cover
Consists in that if in the summer in a heat to suppose on cover top
Any large needle-shaped heat sink (for example)
That efficiency such WITH noticeably increases
Thus, besides, in the dune to saw and cut it is necessary nothing
And  it is possible to cover with beautiful black enamel
Then it will look rather :gigi:

406

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

Not and - the effect will be  (or at all negative). To put - then tin  and  in it to add:D:D

407

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

igrk
Not and - the effect will be  (or at all negative)
.
Let's wait summer - we see... Not long remains:gigi:

408

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

wats0n :
Scalability of such method of cooling of the screw, as a clip to a cover
Consists in that if in the summer in a heat to suppose on cover top
Any large needle-shaped heat sink (for example)
That efficiency such WITH noticeably increases
Thus, besides, in the dune to saw and cut it is necessary nothing
And  it is possible to cover with beautiful black enamel
Then it will look rather :gigi:

you are mistaken. Setting of the additional heat sink on a cover does not affect almost efficiency of cooling. If there will be no air flow sideways. And if such flow to create by means of the exterior fan the additional heat sink will be not necessary.

409

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

Vladimir Grigorievich
I think and without  the present circuit hardly reaches the recommended limit in 60 wasps
Well and if all the same reaches... Something we will think:shuffle:

410

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

wats0n :
I think and without  the present circuit hardly reaches the recommended limit in 60 wasps
Well and if all the same reaches... Something we will think:shuffle:

I too think that anything else it is not necessary to do. Only look for a spacer of such thickness that it was above an overhang on a hard disk. If will be thin, try to lay down in some layers.

411

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

Vladimir Grigorievich
Yes, perhaps I will go on  today smile
Went, bought, installed... Benefited 2 wasps... Too it is good
[img=84x200, 8.1Kb] http://album.foto.ru:8080/photos/sm/193086/2036231.jpg [/img]

412

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

wats0n :
Yes, perhaps I will go on  today smile
Went, bought, installed... Benefited 2 wasps... Too it is good

It is glad for you. A spacer in  9 took, in department of LEDs?

413

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

And than to measure temperature in a dune igrk ?

414

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

Vladimir Grigorievich
It is glad for you. A spacer in  9 took, in department of LEDs?
.
9, 2, but in other department, there where boards different are on sale
In department of LEDs there was only a double-sided adhesive tape
Told that under the order can bring
Any thickness from 0.2 to 2.0 mm (with step 0.2)
To wait - about one month
The size of sheet at them 1000200, cut off how many it is necessary
[img=200x112, 4.4Kb] http://album.foto.ru:8080/photos/sm/193086/2036618.jpg [/img]

415

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

Mike M , hard disk Overheating in Dune Smart D1 see . Methods of a solution of a problem., #347

416

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

wats0n :
9, 2, but in other department, there where boards different are on sale
In department of LEDs there was only a double-sided adhesive tape

"Adhesive tape" - in sense "double-side "?
Thanks for the information.

417

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

Vladimir Grigorievich
"Adhesive tape" - in sense "double-side "?
Yes, the thin transparent

418

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

wats0n :
Yes, thin transparent

I at them such did not see. Only firms 3 (c I am not mistaken), gray color, thickness of 0,19 mm.

419

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

I here recently examining a bottom at dune 1, also one idea was born at me
For extremally hot screw it is possible to carry out generally it for case limits
And besides without any loss of a warranty
Exterior cases and additional
The supply cutout on the back panel is taken out and hides in the case
In the formed hole standard cable S is deduced
And a cable of a supply which certainly should be made most instead of the regular
We buy in the market a white connector-mum which in a board becomes
Cable 22AWG (it is written on regular) our way somewhere 0.33 2
Also we connect this all to a connector of supply SATA
As a result of any  cases and the screw lies on top on a cover

420

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

wats0n :
...
As a result of any  cases and the screw lies on top on a cover

In the presence of the house of active "young talents" at the age from 2 years and is higher can to happen, as in a fairy tale on a chicken of Rjabe: "... The mouse ran, a tail waved..." smile

421

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

wats0n , not  to be engaged in so-called collective farm for the result can satisfy only the collective farmer (to workers of agriculture it concerns only partly). Especially any screw from overheating did not fail yet. wink

422

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

sad wats0n . Once again. Attentively. As much as possible concentrated. We read the previous post. Actually there all is clear, it is necessary to want only. smile

423

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

If I use this player for review of 3-4 films in a week on 1.5 Gb everyone with internal "green" HDD, whether there will be problems with overheating?
The same question, if, for example, 10 hours of on end times per week?

424

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

Djerom :
If I use this player for review of 3-4 films in a week on 1.5 Gb everyone with internal "green" HDD, whether there will be problems with overheating?
The same question, if, for example, 10 hours of on end times per week?

At passive cooling the constant thermal mode is reached somewhere for 1,5-2 hours. I.e., after review of films during this time the maximum temperature in the device which, at the further review, will not rise more will be reached. At an invariance of environmental conditions.
If you take constructive measures to an overheating non-admission, that, what is the time you would not look , overheating of this disk will not be.

425

Re: Hard disk overheating in Dune Smart D1. Methods of a solution of a problem.

At passive cooling the constant thermal mode is reached somewhere for 1,5-2 hours

Vladimir Grigorievich , at me on smart 1 for 45. Review  "AVATAR" the temperature  green HDD WD 500Gb rose to 50 degrees if certainly to trust a smart. In a room temperature of 25 degrees. Did not begin to look further. At review any  and copyings it was not produced. So now  not absolutely beautiful, but very effective system of cooling. smile